A123 Low Voltage Protection ?

[marc993turbo]

Originally Posted by AAngel

In my experience, the packs dump long before the minimum voltage is reached. The only way that I can see hurting an A123 pack is if you accidentally leave it plugged in and the servo just sucks it completely dry.

... thanks for your replies!

I think i am a little bit to cautious when it comes to lipos and fepo4 since my experiences with the last generation nimhs were bad enough...

...drain them a few seconds too long and - buff, the next run the cells have 200mAH capacity less.

So i read all the horror storys about those sensible new technology power cells and became to cautious...

But it seems for me that the fepo4s are much less sensible than the last generation nimhs.

Till now the fepo4´s are running very well.

But the best for me is the way i can charge the cells: put them on my schulze isl 8-936 and puff - they will be charged with full 10Ampere current in a few minutes!

Two packs of A123s and i can run as long as i want!

That was the way i wanted to run my rc cars which was not possible with nimh cells...

So i will take your advice, run till they drop their voltage and stop.

thanks!

Marc.

[Xtremespeed]

Don't be afraid to run them with no voltage protection. I run mine until it dumps. You can't miss it. Feels like a Wal-Mart radio control car when it dumps. Have never seen the voltage drop low enough to cause any damage. A123's are tough.

[zeropointbug]

Yes, they dump super quick, when I do speed runs for a whole runtime, speeding back and forth on a dirt road... then I do one speeding down the road 1/4 mile away, then coming back I suddenly have no power.... OOPS! I have to run and get it because it has no energy left.

I am still surprised how quickly they dump, and there is only maybe 10 millivolts difference between almost fresh pack and the instant before it dumps, very flat discharging curve. I am starting to get the feel for seeing the dump before it happens though, it takes time.

BTW, what do most ppl run their lipo's to? I am hearin various numbers like some do 90% DOD, and others do 80%. I would like to know.